power steering problems
Moderator: FORDification
-
fattyford
- New Member
- Posts: 2
- Joined: Fri Jun 01, 2012 7:05 am
power steering problems
I have a 1970 ford truck with new power steering pump & hoses.Everything is hooked up right, but when I turn the steering wheel it turns about six inches then locks I take off the tension and it turns about six inches and does the same until turn is completed.
-
fireguywtc
- 100% FORDified!
- Posts: 3682
- Joined: Thu Sep 11, 2008 7:37 pm
- Location: North Alabama
Re: power steering problems
from Texas! 
Bill
1967 F-250 LWB 2WD 352 V8, 4spd manual, true duals, 122k original miles (currently being restored)
1970 F-250 4x4 highboy ranger 390 V8, 4spd
2012 F-350 PSD FX4 LWB CC lariat, white
http://www.fordification.com/galleries/ ... hp?uid=602
"If you want to judge a person's true character, give them power."
1967 F-250 LWB 2WD 352 V8, 4spd manual, true duals, 122k original miles (currently being restored)
1970 F-250 4x4 highboy ranger 390 V8, 4spd
2012 F-350 PSD FX4 LWB CC lariat, white
http://www.fordification.com/galleries/ ... hp?uid=602
"If you want to judge a person's true character, give them power."
-
basketcase0302
- 100% FORDified!
- Posts: 6805
- Joined: Thu Jan 26, 2006 7:11 am
- Location: Hawthorne, Florida
Re: power steering problems
from choo-choo town. Sounds to me like it's in the steering box, (even rebuilt ones can have issues) is there a warranty on it? But I'd also try to "burp" the system first. Do this by jacking the front off the ground-and go from lock to lock a few times to make sure it's not air in the hydraulics causing issues.Jeff
http://www.fordification.com/forum/view ... 22&t=46251
SOLD-71 F-350 dually flatbed, 302 / .030 over V-8 with a "baby"C-6, B & M truckshifter, Dana70/4.11 ratio, intermittent wipers, tilt steering, full LED lighting on the flat bed, and no stereo yet (this way I can hear the rattles to diagnose)! SOLD!
Many Ford bumps / one 76' EB / and several dents through the years.
A lot of "oddball" Ford parts collected from working on them for 34 years now!
2008 Ford Escape 4 x 4
http://www.fordification.com/forum/view ... 22&t=46251
SOLD-71 F-350 dually flatbed, 302 / .030 over V-8 with a "baby"C-6, B & M truckshifter, Dana70/4.11 ratio, intermittent wipers, tilt steering, full LED lighting on the flat bed, and no stereo yet (this way I can hear the rattles to diagnose)! SOLD!
Many Ford bumps / one 76' EB / and several dents through the years.
A lot of "oddball" Ford parts collected from working on them for 34 years now!
2008 Ford Escape 4 x 4
-
sargentrs
- 100% FORDified!
- Posts: 9866
- Joined: Fri Jun 22, 2007 9:30 am
- Location: Georgia, Jasper
Re: power steering problems
from Georgia!Randy
1970 F100 Sport Custom Limited LWB, 302cid, 3 on the tree. NO A/C, NO P/S, NO P/B. Currently in 1000 pcs while rebuilding. Project thread: http://www.fordification.com/forum/view ... 22&t=59995 Plan: 351w, C4, LSD, pwr front disc, p/s, a/c, bucket seats, new interior and paint.
1987 F-150 XLT Lariat, 5.0/C6 auto.
1970 F100 Sport Custom Limited LWB, 302cid, 3 on the tree. NO A/C, NO P/S, NO P/B. Currently in 1000 pcs while rebuilding. Project thread: http://www.fordification.com/forum/view ... 22&t=59995 Plan: 351w, C4, LSD, pwr front disc, p/s, a/c, bucket seats, new interior and paint.
1987 F-150 XLT Lariat, 5.0/C6 auto.
-
wndsofchng06
- Preferred User
- Posts: 402
- Joined: Fri Jun 01, 2012 7:41 pm
- Location: Durham, NC
Re: power steering problems
welcome....
Was it steering ok before you replaced the pump?:
Was it steering ok before you replaced the pump?:
-
tidybowl
- New Member
- Posts: 75
- Joined: Tue Feb 21, 2012 9:00 pm
- Location: fullerton, ca
Re: power steering problems
Welcome to the world of Bump fun from SoCal. Sounds like a hydraulic lock up. If you have enough hose, remove the return line to the pump put a bucket under it to catch to fluid and put extra hose on the pump that can rise above the pump (a second had is always helpful. Have PS fluid and a funnel at the pump. Start the motor. With a second hand adding fluid to the pump, quickly check the steering. If it works, and you have good flow on your return, the pump is defective. If you have little or no flow on the return line the steering gear may be plugged. I've used air to back flush the steering gear. Repeat the the procedure. Good luck
1970 F-250 Camper Special 390/C-4 auto 289K miles, 1992 Explorer 4x4 229K Miles, 2000F-150 4.2L V6 154K miles
-
fattyford
- New Member
- Posts: 2
- Joined: Fri Jun 01, 2012 7:05 am
Re: power steering problems
Thanks guys looks like I had an air lock in the hose, good burp everything work well.
-
basketcase0302
- 100% FORDified!
- Posts: 6805
- Joined: Thu Jan 26, 2006 7:11 am
- Location: Hawthorne, Florida
Re: power steering problems
love easy fixes! 
Jeff
http://www.fordification.com/forum/view ... 22&t=46251
SOLD-71 F-350 dually flatbed, 302 / .030 over V-8 with a "baby"C-6, B & M truckshifter, Dana70/4.11 ratio, intermittent wipers, tilt steering, full LED lighting on the flat bed, and no stereo yet (this way I can hear the rattles to diagnose)! SOLD!
Many Ford bumps / one 76' EB / and several dents through the years.
A lot of "oddball" Ford parts collected from working on them for 34 years now!
2008 Ford Escape 4 x 4
http://www.fordification.com/forum/view ... 22&t=46251
SOLD-71 F-350 dually flatbed, 302 / .030 over V-8 with a "baby"C-6, B & M truckshifter, Dana70/4.11 ratio, intermittent wipers, tilt steering, full LED lighting on the flat bed, and no stereo yet (this way I can hear the rattles to diagnose)! SOLD!
Many Ford bumps / one 76' EB / and several dents through the years.
A lot of "oddball" Ford parts collected from working on them for 34 years now!
2008 Ford Escape 4 x 4
-
Kurt Combs
- Blue Oval Guru
- Posts: 1341
- Joined: Sat Apr 22, 2006 11:12 pm
- Location: California, Lakeport
Re: power steering problems
from northern California! Glad to hear you fixed your problem.Kurt
1972 F-250
1972 F-250